Saratov Airlines crash: No lessons learned from Air France 447
Barely a month ago, the press hailed the year of 2017 as the safest year in history for air passenger transportation. The aviation industry predicted a rosy picture of a future where there wouldn’t be any more aircraft accidents, basically because of the increasing automation, supposed to make commercial aviation more predictable and secure.
Two accidents in one week
But then, as Icarus himself had flown to close to the sun, one deadly accident after the other started to occur. On new years eve, a Nature Air Cessna, crashed in Costa Rica, leaving ten American citizens dead. On February 11, an Ukraine-built Antonov plane of Saratov Airlines crashed near Moscow killing 71 people on board. A week later, on February 18, a French built ATR Turboprop crashed with 65 victims on board in Iran. Although in all three accidents, bad weather conditions were perceived as contributing factors, one important conclusion is that there seem to be a dramatic increase in a phenomenon tagged by the ICAO as Loss of Control in Flight (LOC-I) where pilots simple lose control of their aircraft.
The similarities between the Saratov Airlines crash near Moscow on February 11 and the Air France 447 from Rio to Paris in 2009 are too striking to ignore. Although the full investigation into the accident of Flight Saratov 703 is not finished yet, preliminary information from the recovered Flight Data Recorder, point out that the accident was caused by the malfunctioning of a frozen speed sensor (pitot tube), which lead to contradictory information on the pilot’s instruments, after which the Autopilot shut down and the pilots lost control of the aircraft. Exactly the same thing that happened in 2009 with the Air France 447, except that the situation of Loss of Control took place at an altitude of 34.000 feet. The Russian Antonov on the other side, had recently taken off and was climbing at an altitude of 4000 feet, when the event occurred.
Erroneous speed readings leading to mayhem in cockpit
After take-off, the Antonov’s speed sensor 1 started to display considerable lower speeds than the stand-by sensor 2. At some point, at an altitude of 6000 feet, the speed recorded by the left sensor was nearing zero, while the right sensor was recording 550 km per hour, which is a normal speed for that altitude. What most likely happened was that the left sensor got clogged with ice and stopped measuring the real speed, but the stand-by pitot was probably working perfect. The disagreement between two sources lead to the disengagement of the Autopilot.
After that things got from bad to worse and the plane made a strong pitch-down maneuver of more than 30 degrees, impacting with the ground 3 minutes after the disconnection of the Autopilot. (on Flight 447 the sequence of the accident took 4 minutes).
De-icing system unoperative
According to the Russian investigators, the crew of the Antonov 148, forgot to switch on the de-icing system of the speed sensors before take-off. This would mean an important omission on the checklist and a so-called “human error”. On Flight AF447, the freezing of the pitot tubes was a recurring technical problem on the Airbus (which lead to the a worldwide replacement program of Thales speed probes on the A-330 models). But the outcome in both accidents was the same: the contradictory speed information confused the pilots. The loss of a reliable speed information should not necessarily lead to an accident, this event occurs often in aviation and on every aircraft there are protocols for Unreliable Speed Situations.
On the Antonov the difference in speed measured by the two sensors was so blatant that one could wonder why the pilots did not trust the stand-by sensor on the right and ignored the left one. But just as on Flight AF447, the pilots just could not work it out after the Autopilot was disengaged. Too much stress? Too many alarms going off at the same time? They were not able to interpret the contradictory information on their instruments.
Currently most pilots fly almost exclusively on Automatic Pilot (AP) and manual flight has become very rare, because airlines recommend to fly as much on AP as possible, to save fuel and to maximize comfort for the passengers. That is, until the Automatic Pilot stops working. The main conclusion of the French Investigative Board for Airline Accidents (BEA) after the crash of the AF447, was that airlines had to improve training for situations of loss of reliable airspeed. (*)
Apparently this has not happened. Stjepan Bedic, a safety manager and a compliance monitoring manager at Kermas Aviation, the Saratov accident does not reflect well on the current state of Russian civil aviation. “Even though it is reasonable to assume that the direct cause of the accident is failure of the crew to engage the heaters of the pitot-static system, the job of the safety management system, as well as investigation is to find the root cause. Failure to engage the heaters is just a symptom. A more serious fact, that the pilots were not able to fly the airplane with unreliable airspeed indication is also a symptom.” According to Bedic, any seasoned pilot should be able to fly a plane with unreliable speed indications: “Forgetting to turn on the heaters should have not resulted in a crash. Flying with unreliable indication is a part of aviation primary school and practised in basic IFR-training.”
“It would be irresponsible to jump to conclusions regarding the root cause,” he says “however, the correct procedure for preventing such accidents in the future, would lead towards evaluation of safety standards in the civil aviation authority and the airline management.” According to Bedic, some important questions arise after the Saratov-accident: “Who is the authority who audited the pilots’ training system? How were the pilots screened? How strict are they with implementing the Standard Operational Procedures (SOP)?” And most of all: “Did they implement the upset recovery training. This became an industry standard after the AF crash.”
(*) page 208 of the BEA report on AF447 : The possible related loss of associated speed references doubtless constitutes an aeroplane handling difficulty for crews that are not prepared. Training does not adequately draw attention of crews to the precise identification of the type of reconfiguration and of the level of protection and on the necessity to monitor the trajectory and the primary parameters.
Rossiya Boeing 777 makes emergency landing over engine issue
A Rossiya Boeing 777 was forced to make an emergency landing at Moscow-Sheremetyevo Airport after reporting an engine pr...
New DoT report finds “limitations” in FAA certification of Boeing 737 MAX
A new report, published by the Office of Inspector General (OIG) of the DoT found deficiencies in the FAA's cer...
Groundworker blinded by aircraft landing lights at St Petersburg airport
An investigation was opened after a groundworker of Pulkovo Airport in St. Petersburg suffered an eye injury from landin...